HOME  »  Andre's 1968 Triumph GT6 MK1 - 2006 Photo Gallery » 03 Jan 2006 Clutch Slave Rebuild  (8 Slides)     [Page 1 of 1] :: Jump To  
  Up one level  
DCP04924 * Tonight I could not get anything going well with the trans, so I rebuild my clutch slave.
Here we can see the slave taken apart with the new rebuild kit pieces. * Tonight I could not get anything going well with the trans, so I rebuild my clutch slave.
Here we can see the slave taken apart with the new rebuild kit pieces. * 1152 x 864 * (230KB)
DCP04925 * The old seal which was in good shape. * The old seal which was in good shape. * 1152 x 864 * (262KB)
DCP04926 * The cylinder bore is not too bad, some light rust rings. I'll run it, but if I notice problems I know where to look. * The cylinder bore is not too bad, some light rust rings. I'll run it, but if I notice problems I know where to look. * 1152 x 864 * (209KB)
DCP04927 * This is the pipe I bought from Home Depot to fit the rear bearing into place. Thanks Paul T for the tip. * This is the pipe I bought from Home Depot to fit the rear bearing into place. Thanks Paul T for the tip. * 1152 x 864 * (245KB)
DCP04928 * The issue with the trans was I could not get collar split bearings into place. So rather then fight with cold metal and get upset I did my clutch slave. * The issue with the trans was I could not get collar split bearings into place. So rather then fight with cold metal and get upset I did my clutch slave. * 1152 x 864 * (217KB)
  DCP04924  
  DCP04925  
  DCP04926  
  DCP04927  
  DCP04928  
DCP04929 * Once cleaned and prepped I pour some DOT5 brake fuild into the slave and lubed the piston and rubber seal. * Once cleaned and prepped I pour some DOT5 brake fuild into the slave and lubed the piston and rubber seal. * 1152 x 864 * (330KB)
DCP04930 * Clip and cap installed. * Clip and cap installed. * 1152 x 864 * (329KB)
DCP04932 * I taped both ends to avoid dust and spills. * I taped both ends to avoid dust and spills. * 1152 x 864 * (309KB)
  DCP04929  
  DCP04930  
  DCP04932  
Album last updated on May 05, 2009 - 09:46 PM
Powered by Jalbum 8.2 and BluPlusPlus skin
GT6.ca